An airline pilot reveals why the Boeing 757 is truly unique
American, Delta, and United all operate large fleets of the airplane.
Even though the Renton, Washington-based plane maker booked more than 1,000 orders for the jets over its two decades in production, it was never a hot seller.
By the early 2000's, sales of the 757 had all but dried up, and Boeing put the plane out to pasture in 2004.
Although many of the planes are pushing 25 years of service, airlines are hanging onto their 757s. For instance, Delta, who has spent big bucks on a fleet of new jets, recently refurbished the cabins of its aging 757s instead of replacing them with newer planes.
So why are its customer's so loyal? Is the 757 such as good? To get some answers, Business Insider recently spoke with author and Boeing 757 pilot Patrick Smith about the plane.
"There's no denying the 757 is an old plane that was designed in the late 1970s, but the versatility of the plane is remarkable and unmatched," Smith, the author of the book Cockpit Confidential, told Business Insider in an interview. "It's profitable on both short-haul domestic as well as trans-Atlantic routes."
Boeing is currently marketing a new stretched variant of its long-serving 737 - called the MAX 9 - as a potential replacement for the 757. Now, there's talk that Boeing may make the 737 even larger to match get closer to the 757's capacity.
"Boeing is trying to push the 737 as a viable 757 replacement," Smith said, "In some respects it can and in some respects it can't."
For instance, the 737 simply isn't capable of the same kind of engine performance as the 757.
According to Smith, the 737 falls way short of the 757 in terms of runway performance. The 737 requires a much higher takeoff speed and much more runway to get off the ground.
"The 757 can be off the ground in 4,000 ft. and under 140 knots," he told us. However, Smith recounts being in the cockpit jump seat of a 737 as two other pilots were flying. During takeoff, the author noticed that the plane didn't lift off until 160 knots and used up much more runway.
Furthermore, the 757 can comfortably climb straight to its cruising altitude. On the other hand, the 737 requires a step climb procedure that calls for the plane to climb to a certain altitude and burn off some fuel to lighten the load before climbing to higher altitude.
Runway performance matters. Especially when it comes to the type of flying the 757 and the 737 are asked to perform - trans-continental or oceanic flights with a full payload.
The reality is that Smith believes the Boeing 737 is a good plane, but is being asked to take on a mission the design wasn't meant to perform.
"The Boeing 737 was essentially conceived as a small regional jet nearly decades ago," Smith told us. "It's an extremely popular plane, but it's being asked to perform missions it wasn't designed for."
As a result, Boeing is simply not in a position to bolt bigger engines onto the 737. Since its introduction in the 1960s, Boeing has been installing larger and larger engines on the 737 as the size of the plane grew. Unfortunately, the amount of room underneath the wing hasn't changed. Thus, Boeing has all but maxed out on the size of the engines it can mount on the 737 without completely redesigning the plane's under carriage.
Instead of a stretched 737, Smith believes Boeing should have gone for an updated version of the 757 at sometime during its production run.
"Somewhere along the way, had Being just re-engined the 757 with a new cockpit and new internal system, it could have been a big hit," Smith told us.
Representatives from Boeing were not immediately available for comment.
"It's a 6-across narrow body that's long and thin," Smith said. "And for passengers, it can take a long time to board and disembark."
In addition, the 757's cockpit is pretty old-fashioned with compared to modern airliners such as the 737 MAX. The controls of the 757 are also much heavier for pilots than its sibling - the Boeing 767. The 757 and 767 were developed at the same time and features virtually identical cockpits.
Finally, the Boeing 757 leaves a massive amount of wake turbulence as it flies - forcing air traffic controllers to keep other planes far away from passing 757s.
"No one know really why, but the 757 has really strong wake turbulence," Smith told us. "The early 757s had worse wake turbulence than the 747."Although Smith added that the addition of winglets on later 757s have greatly decreased the wake turbulence.The Boeing 757 is aircraft that's come and gone. It's served it tour of duty with honor and distinction. Now, it's time for Boeing to find a replacement worthy of stepping into its shoes.